| Tittel: | Braathens S.A.F.E : BOEING 737 MAINTENANCE MANUAL - VOLUME 7 | | Forfatter: | Braathens S.A.F.E | | Materialtype: | Manual/Sivil | | Signatur: | 21-A-6 | | Utgitt: | Renton, Washington : The Boeing Company, Commercial Airplane Division | | Omfang: | upag. | | Emneord: | Boeing 737 / Braathens / Maintenance manual | | Lokal Note (gave): | Braathens | | Materialbetegnelse: | Technical Handbook | | Materialbetegnelse: | Perm | | Note: | Gift from former Braathens
Last Revision to Chapter 51, dated Oct. 20/90
Last Revision to Chapter 52, dated Jun. 20/90
Last Revision to Chapter 53, dated Jun. 20/90
Last Revision to Chapter 54, dated Oct. 20/90
Last Revision to Chapter 55, dated Oct. 20/90
Last Revision to Chapter 56, dated Oct. 20/90
Last Revision to Chapter 54, dated Feb. 20/90
Written in front of binder: "6022007 Ex 9" | | Innhold: | TABLE OF CONTENTS:
CHAPTER 51 STRUCTURES-GENERAL
51-00 STRUCTURES
Description and Operation
Engine Fairing
Empennage
Fuselage
Wings
Wing to Fuselage Attachment
FINISHES
51-21-0 PROTECTIVE FINISHES
Description and Operation
Hydraulic Fluid Contamination Areas
Exterior Decorative Markings
Protective Finishes
Paint Stripping
Prepaint Cleaning and Pretreatment
Corrosion Removal and Control
Alodizing
Chemical and Solvent Resistant Finish
Clear Hydraulic Fluid Resistant Finish
Conductive Coating System for Exterior Reinforced Surfaces
Abrasion Resistant Teflon Finish
Water Displacing Corrosion Inhibiting Compound
Floor Track Corrosion Prevention
Velvet Coating for Nonglare Areas
Abrasion Resistant Molybdenum Disulfide Finish
Skin and Fastener Corrosion Control
High Temperature Coating for Titanium
Nonskid Surface
Heat, Weather and Oil Resistant Inorganic Protective Coating
Decorative Paint System
SEALS
51-31-0 SEALS AND SEALING
Description and Operation
Definitions of Levels of Sealing
Maintenance Practices
Accelerating Curing
Apply Aerodynamic Smoother
Apply Electrical Fitting Seal
Apply Fastener Seal
Apply Faying Surface Seal
Apply Fillet Seal
Apply Fuel Seal
Apply Hole and Slot Seal
Apply Injection Seal
Prepare for Sealing
Protection of Sealing Materials
Special Sealing Method for Corrosion Protection
DRAINAGE
51-41-0 AIRFRAME DRAINAGE
Description and Operation
External Drainage - Inspection/Check
Internal Drainage - Inspection/Check
Fuselage Drain Valve - Removal/Installation
RUB PADS
51-51-0 BONDED RUB PADS
Phenolic and Stainless Steel Rub Pads
Approved Repairs
Teflon Rub Pads
Approved Repairs
CHAPTER 52 DOORS
52-00 DOORS
Description and Operation
Cargo Doors
Door Warning System
Emergency Exits
Entrance Stairs
Aft Entry Door and Airstair
Forward Airstair
Fixed Interior Doors
Control Cabin Door
Lavatory Doors
Landing Gear Doors
Passenger/Crew Doors
Service Doors
Galley Service Doors
Miscellaneous Serivce Doors
52-09-100 DOOR SEALS
Approved Repairs
Diaphragm Seals
Removal/Installation
Flap Type Mechanical Seals
Removal/Installation
Bulb Type Mechanical Seals
Removal/Installation
Diaphragm - Mechanical Seals
Removal/Installation
Aerodynamic Seals
Removal/Installation
Acoustic and Thermo Seals
Removal/Installation
Light Seals
Removal/Installation
PASSENGER/CREW
52-11-0 FORWARD ENTRY DOOR
Description and Operation
Door Lining and Insulation
Handle Mechanism
Latch Assembly
Latching Crank and Door Locking Crank
Lower Hinge Assembly
Spring Assist Torque Tube
Upper Hinge Assembly
Removal/Installation
Adjustment/Test
Inspection/Check
Approved Repairs
Forward Entry Door
Trouble Shooting
Forward Entry Door Hinge Arms
Removal/Installation
Forward Entry Door Guide Arm Roller
Removal/Installation
Forward Entry Door Lining and Insulation
Removal/Installation
Forward Entry Door Assist Spring
Removal/Installation
52-13-0 AFT ENTRY DOOR
Description and Operation
Removal/Installation
Adjustment/Test
Inspection/Check
Approved Repairs (Ref 52-41-0)
Aft Entry Door Hinge Arms
Removal/Installation
Aft Entry Door Lining
Removal/Installation
Aft Entry Door Guide Arm Roller
Removal/Installation
Aft Entry Door Structure Torque Tube
Removal/Installation
52-20-0 EMERGENCY EXIT
Description and Operation
52-21-0 EMERGENCY EXIT HATCH
Description and Operation
Removal/Installation
Adjustment/Test
Inspection/Check
Emergency Exit Hatch Lining [4]
Removal/Installation [5]
CARGO
52-31-0 CARGO COMPARTMENT DOORS
Description and Operation
Balance Mechanism
Latching Mechanism
Removal/Installation
Inspection/Check
Approved Repairs
Cargo Compartment Door Balance Mechanism
Removal/Installation
52-32-0 MAIN CARGO DOOR [1]
Description and Operation
Control Panel
Control Valve
Flow Limiters
Hand Pump
Latch and Lock Mechanism
Lift Mechanism
Relief Valve
Shutoff Valve
Trouble Shooting
Maintenance Practices
Adjustment/Test
Main Cargo Door Assembly
Removal/Installation
Adjustment/Test
Main Cargo Door Hinge
Removal/Installation
Main Cargo Door Latch Actuator
Removal/Installation
Main Cargo Door Lift Actuator
Removal/Installation
Main Cargo Door Lift Actuator Linkage
Removal/Installation
Inspection/Check
Main Cargo Door Hand Pump
Removal/Installation
Main Cargo Door Hydraulic Control Valve
Removal/Installation
Main Cargo Door Shutoff Valve
Removal/Installation
Main Cargo Door Lining
Removal/Installation
Main Cargo Door Insulation
Removal/Installation
Main Cargo Door Canopy Position Switches
Adjustment/Test
Main Cargo Door Locked Switch
Adjustment/Test
Main Cargo Door Position Switch
Adjustment/Test
Main Cargo Door No. 3 and 6 Lockpin Switches [3]
Adjustment/Test
SERVICE
52-41-0 GALLEY SERVICE DOORS
Description and Operation
Door Lining and Insulation
Handle Mechanism
Latch Assembly
Latching Crank and Door Locking Crank
Lower Hinge Assembly
Upper Hinge Assembly
Removal/Installation
Adjustment/Test
Inspection/Check
Approved Repairs
Galley Service Door Hinge Arms
Removal/Installation
Galley Service Door Guide Arm Roller
Removal/Installation
Galley Service Door Lining and Insulation
Removal/Installation
Galley Service Door Structure Torque Tube
Removal/Installation
52-48-11 AIR CONDITIONING ACCESS DOORS
Description and Operation
Latching Mechanism
Approved Repairs
52-48-21 APU ACCESS DOOR
Description and Operation
Latching Mechanism
52-48-31 LOWER NOSE COMPARTMENT ACCESS DOOR
Description and Operation
Latching Mechanism
Removal/Installation
52-48-41 ELECTRONIC EQUIPMENT COMPARTMENT EXTERNAL ACCESS DOOR
Description and Operation
Latching Mechanism
Removal/Installation
Adjustment/Test
52-49-0 MISCELLANEOUS EXTERIOR SERVICE DOORS
Description and Operation
Section 48 Access and Blowout Door
Removal/Installation
Adjustment/Test
Pressure Fueling Station Access Door
Adjustment
Tire Burst Protector Screen Doors [6]
Maintenance Practices
Removal/Installation
FIXED INTERIOR
52-51-0 CONTROL CABIN DOOR
Description and Operation
Control Cabin Door Lock Switch/Light
Removal/Installation
Adjustment/Test
Control Cabin Door Lock
Removal/Installation
Control Cabin Door Emergency Exit Panels
Removal/Installation
52-52-0 LAVATORY DOORS
Description and Operation
ENTRANCE STAIRS
52-52-0 FORWARD AIRSTAIR AND DOOR
Description and Operation
Trouble Shooting
Adjustment/Test
52-61-100 FORWARD AIRSTAIR
Description and Operation
Actuation System
Carriage
Electrical System
Handrails
Handrails Extensions
Rail Assemblies
Stair
Manual Operation
Removal/Installation
Forward Airstair Actuator
Removal/Installation
Forward Airstair Ballscrew
Removal/Installation
Forward Airstair Motor
Removal/Installation
Forward Airstairn Carriage Step Actuating mechansim
Adjustment/Test
Forward Airstairn Retract Limit Switches
Removal/Installation
Adjustment/Test
Forward Airstair Extend Limit Switches
Removal/Installation
Adjustment/Test
Forward Airstair Lower Ladder Operating Switch
Removal/Installation
Adjustment/Test
Forward Airstair Lower Ladder Closed Switch
Removal/Installation
Adjustment/Test
Forward Airstair Manual Handrail Stowed Switches
Removal/Installation
Adjustment/Test
Forward Airstair Lower Ladder Lock
Adjustment/Test
Forward Airstair Door Slow-Down Operating Limit Switch
Removal/Installation
Adjustment/Test
Forward Airstair Speed-Up Limit Switch [2]
Removal/Installation
Adjustment/Test
Forward Airstair Angle Gearbox
Removal/Installation
52-61-500 FORWARD AIRSTAIR DOOR
Description and Operation
Actuator
Airstair Door Assembly
Carriage
Carriage Tracks
Door Latch and Control
Door Tracks
Electrical System
Removal/Installation
Forward Airstair Door Carriage
Removal/Installation
Forward Airstair Door Actuator
Removal/Installation
Forward Airstair Door Lock Mechanism
Removal/Installation
Adjustment/Test
Forward Airstair Door Actuator Snubber
Removal/Installation
Forward Airstair Door Normal System Motor
Removal/Installation
Forward Airstair Door Standby System Motor
Removal/Installation
Forward Airstair Door Closed Limit Switches
Removal/Installation
Adjustment/Test
Forward Airstair Door Open Limit Switches
Removal/Installation
Adjustment/Test
DOOR WARNING
52-71-0 DOOR WARNING SYSTEM
Description and Operation
Trouble Shooting
Adjustment/Test
LANDING GEAR
52-81-0 MAIN LANDING GEAR DOORS
Description and Operation
52-82-0 NOSE LANDING GEAR DOORS
Description and Operation
[1] Passenger/Cargo Convertible Airplanes Only
[2] ALL EXCEPT LN-SUS and LN-SUP
[3] Airplanes incorporating SB 52-1060
[4] Airplanes with Hatrack-Type Interior
[5] Airplanes with Wide-Body Look or Carry-All Compartment Interior
[6] Airplanes with Tire Burst Screens
CHAPTER 53 FUSELAGE
53-00 FUSELAGE
Description and Operation
53-10-0 MAIN FRAME
Description and Operation
Primary Structure
53-11-0 FRAMES AND BULKHEADS
Description and Operation
53-12-0 STRINGERS AND OTHER LONGITUDINAL MEMBERS
Description and Operation
Keel Beam Blowout Panel
Removal/Installation
52-13-0 STRUCTURE AROUND OPENINGS
Description and Operation
53-14-0 WHEEL WELLS
Description and Operation
Cleaning/Painting
Main Wheel Well Fairing Blowout Panel
Removal/Installation
AUXILIARY STRUCTURE
53-21-0 PASSENGER CABIN FLOORS
Description and Operation
Removal/Installation
Approved Repairs
Water Barrier
Approved Repairs
53-22-0 FIXED PARTITIONS
Description and Operation
53-23-1 AUXILIARY FUEL TANK STRUCTURE [1]
Removal/Installation
Inspection/Check
PLATES AND SKIN
53-31-0 SKIN
Description and Operation
Vortex Generators
Removal/Installation
Stabilizer to Body Front Spar Sliding Seal
Removal/Installation
ATTACH FITTINGS
53-41-0 STRUCTURE ATTACHMENT FITTINGS
Description and Operation
Door Attachment Fittings
Landing Gear Attachment Fittings
53-42-0 EQUIPMENT ATTACHMENT FITTINGS
Description and Operation
Miscellaneous Equipment Attachment Fittings
Seat Attachment Fittings
Passenger Cabin and Cargo Compartment Tracks
AERODYNAMIC FAIRINGS
53-51-0 FILLET FAIRINGS
Description and Operation
Nose Gear Deflector Fairings
Wing to Body Fairings
Wing-to-Body Fairing Blowout Panel
Removal/Installation
Aft Wing-to-Body Fairing
Removal/Installation
53-52-0 NOSE RADOME
Description and Operation
Removal/Installation
Cleaning/Painting
Approved Repairs
Nose Radome Erosion Coating
Approved Repairs
Glide Slope Antenna Director Bar
Removal/Installation
53-53-0 TAIL CONE
Removal/Installation
[1] DT D2-TAH
BU LN-SUB, LN-SUK, LN-SUT
HV PH-TVR, PH-TVS
CHAPTER 54 NACELLES/PYLONS
54-00 NACELLES/PYLONS
Description and Operation
54-10-02 STRUT DRAINS
Inspection/Check
MAIN FRAIM
54-11-0 ENGINE FIREWALL
Description and Operation
PLATES AND SKIN
54-31-0 ENGINE COWLING
Description and Operation
Movable Cowls and Fixed Cowls
Nose Dome and Nose Cowl
Thrust Reverser Fairing
ATTACH FITTINGS
54-41-0 ENGINE ATTACH FITTINGS
Description and Operation
Inspection/Check
Forward Engine Mount
Removal/Installation
Fiber Washer
Removal/Installation
FILLETS/FAIRINGS
54-51-0 ENGINE-TO-WING FAIRING
Description and Operation
Engine-To-Wing Forward Fairing
Removal/Installation
Adjustment/Test
Engine-To-Wing Aft Fairing
Removal/Installation
Engine-To-Wing Midfairing
Removal/Installation
CHAPTER 55 STABILIZERS
55-00 STABILIZERS
Description and Operation
55-10-0 HORIZONTAL STABILIZER
Description and Operation
Stabilizer Structure
Inspection/Check - Free Play Limits (Ref 27-41-31)
Removal/Installation (Ref 27-41-11)
55-20-0 ELEVATOR
Description and Operation
Elevators
Elevator Control Tabs
55-30-0 VERTICAL STABILIZER (FIN)
Description and Operation
Vertical Fin Structure
Removal/Installation
Inspection/Check
Vertical Stabilizer (Fin) Attach Fittings
Approved Repairs
Dorsal Fin
Removal/Installation
Vertical Stabilizer (Fin) Leading Edge
Removal/Installation
Vertical Stabilizer (Fin) Tip
Removal/Installation
55-40-0 RUDDER
Description and Operation
Rudder Structure
55-50-0 ATTACH FITTINGS
Description and Operation
Elevator Attach Fittings
Horizontal Stabilizer Center Section Truss Attach Fittings
Horizontal Stabilizer Outboard Section Attach Fittings
Rudder Attach Fittings
Vertical Fin Attach Fittings
CHAPTER 56 WINDOWS
56-00 WINDOWS
Description
56-10-0 FLIGHT COMPARTMENT
Description and Operation
56-11-0 FIXED CONTROL CABIN WINDOWS
Description and Operation
Window No. 1
Window No. 2
Window No. 3
Window No. 4
Window No. 5
Fixed Window Seal and Sealants
Manintenance Practices
Damage Criteria
Approved Repairs
Aerodynamic Smoother (Sealant)
Fairing Compound
Window No. 1
Removal/Installation
Inspection/Check
Window No. 3
Removal/Installation
Inspection/Check
Approved Repairs
Window No. 4 and 5
Removal/Installation
Inspection/Check
56-12-0 SLIDING CONTROL CABIN WINDOWS
Description and Operation
Window No. 2 (Pilots' Sliding Windows)
Window No. 2 Seals and Sealants
Window No. 2 (Pilots' Sliding Windows) Emergency Exit
Release mechanism
Window No. 2 (Sliding Window)
Trouble Shooting
Removal/Installation
Adjustment/Test
Inspection/Check
Approved Repairs
CABIN
56-21-0 PASSENGER CABIN WINDOW
Description and Operation
Servicing
Removal/Installation
Inspection/Check
Approved Repairs
Passenger Cabin Windows Plate (Plug)
Removal/Installation
56-22-0 EMERGENCY EXIT HATCH WINDOW
Description and Operation
Removal/Installation
Inspection/Check
DOOR
56-31-0 DOOR-MOUNTED WINDOWS
Description and Operation
Removal/Installation
Inspection/Check
Approved Repairs
INSPECTION AND OBSERVATION
56-41-0 VIEWERS AND OBSERVATION WINDOWS
Description and Operation
APU Fire Extinguisher Bottle Window
Cargo Compartment Observation Windows
Main Gear Downlock Viewer Window
Nose Gear Downlock Viewer Window
Cargo Compartment Observation Windows
Removal/Installation
Inspection/Check
Main Gear Downlock Viewer Window
Removal/Installation
Inspection/Check
Nose Gear Downlock Viewer Window
Removal/Installation
Inspection/Check
APU Fire Extinguisher Bottle Window
Removal/Installation
CHAPTER 57 WINGS
57-0 WINGS
Description and Operation
57-10-0 MAIN FRAME
Description and Operation
Center Wing Box
Wing Boxes
57-11-0 WING SPARS
Description and Operation
Wing Front Spars
Wing Rear Spars
57-12-0 WING RIBS
Description and Operation
Rib Access Openings
Special Ribs
Standard Ribs
57-13-0 WING STRINGERS
Description and Operation
57-14-0 CENTER WING BOX
Description and Operation
Center Wing Box Structure
Removable Fuel Cells
Backing Boards
Center Wing Cavity Backing Boards [1]
Removal/Installation
57-15-0 LANDING GEAR SUPPORT BEAMS
Description and Operation
Landing Gear Support Beam Structure
Removal/Installation
Inspection/Check
57-20-0 AUXILIARY STRUCTURE
Description and Operation
Leading Edge Structure
Trailing Edge Structure
Wingtip Structure
57-21-11 REMOVABLE WING TIP
Removal/Installation
Approved Repairs
57-30-0 PLATES/SKIN
Description and Operation
Primary Wing Tip
Secondary Wing Tip
Inspection/Check
Fuel Tank and Boost Pump Access Panel Openings
Boost Pump Access Door
Removal/Installation
57-32-0 WING VORTEX GENERATORS
Description and Operation
Inspection/Check
57-40-0 ATTACH FITTINGS
Description and Operation
57-41-0 WING TERMINAL FITTINGS
Description and Operation
Wing Box to Center Wing Box Connection
Upper Aft Wing-to-Fuselage Shim
Removal/Installation
57-42-0 FLIGHT CONTROL ATTACH FITTINGS
Description and Operation
57-43-0 LANDING GEAR ATTACH FITTINGS
Description and Operation
57-44-0 ENGINE HOST ATTACH FITTINGS
Description and Operation
Removal/Installation
57-50-0 FLIGHT SURFACES
Description and Operation
Ailerons
Description and Operation
Leading Edge Flaps
Leading Edge Slats
Spoilers
Trailing Edge Flaps
57-51-0 AILERONS
Description and Operation
Ailerons
Aileron Balance Tabs
57-52-0 TRAILING EDGE FLAPS
Description and Operation
Aftflap
Foreflap
Midflap
57-53-0 LEADING EDGE FLAPS
Description and Operation
57-54-0 LEADING EDGE SLATS
Description and Operation
57-55-0 SPOILERS
Description and Operation
Flight Spoilers
Ground Spoilers
[1] Airplane with center tank fuel cells | | Eier: | Norsk Luftfartsmuseum | | |
|
| 1.ex | Ikke til utlån | | Norsk Luftfartsmuseum | Norsk Luftfartsmuseum | | 21-A-6 | |
|
|